1. INTRODUCTION Traction-drive has been developed as, for example, an element of a continuously variable transmission (CVT) for automobiles. An oil film is constantly formed in the contact between rolling elements that transmit power to each other. This oil film is solidified and sheared at a GPa-level contact pressure, and its shearing properties are af fected by the heat-generated temperature rise itself. That is, the temperature in the contact area can be considered the most important factor in estimating traction transmission force. With the goal of improving estimation accuracy for the maximum traction coefficient, the authors have been working to estimate and measure the temperature rise in the contact area using a thin film temperature sensor [ 1, 2]. One of the calculation methods that precisely handles temperature rise in oil film is Thermal- Elasto Hydrodynamic Lubrication (T-EHL) [3], which is a method that couples an energy equation with normal EHL analysis. However, this numerical analysis requires such advanced and large-scale calculation that the calculation method used for convergence could become a research subject in itself. In CVT for automobiles, sequentially estimating the maximum traction coefficient under driving conditions and properly controlling the normal force at the contact improves power transmission efficiency . However, incorporating large-scale calculation into such sequential control is certainly impossible. Therefore, it is necessary to build a model with the goal of understanding the physical characteristics of μ and expressing μ in as simple calculation as possible while retaining its characteristics. Through a traction coefficient estimation method using a calculation model suggested in the past [ 1], estimation accuracy was improved by combining the viscosity and plasticity regions of an oil film inside the contact ellipse in a μ measurement test using a four-roller experimental apparatus. However, under certain conditions, the change slope of μ relative to the slip ratio still differed from measured values (See in Figure 1). That is, μ estimation accuracy was observed to decrease as the heat generated by shearing inside the oil film increased. It seems that the physical characteristics of μ necessary under certain conditions could not be sufficiently expressed as the model was simplified. The slip ratio in the contact of a typical variator unit is not large, that is under 1%. However, as the slip Improvement of Temperature Prediction Method for Traction Contact Toshinari Sano Toyota Motor Corporation Masashi Inoue Nippon Soken Inc Fumihiro Itoigawa Nagoya Institute of Technology ABSTRACT This report proposes a method of improving the temperature prediction model for traction drive contact portion in order to improve prediction accuracy of the maximum traction coefficient, and then describes verification of this method. In our previous report, a method of estimating the maximum traction coefficient by expressing conditions inside the contact ellipse using a simple combination of viscosity and plasticity was proposed. For the rise in oil film temperature, a calculation model is used that considers maximum temperature to be the typical value. Furthermore, a thin film temperature sensor technology was developed to directly measure the temperature of traction contact of a four-roller experimental apparatus and a variator in an actual transmission, and its validity was confirmed. When measured values of the traction coefficient μ were compared with calculated ones, it was learned that μ estimation accuracy decreased under certain low-contact-pressure and high-sliding conditions. The factor that caused μ estimation accuracy to decrease under these load conditions was presumed to be an error in oil film temperature estimation. Therefore, by partially improving the temperature prediction model, that factor was identified and examined. In the end, the maximum traction coefficient was est

pdf文档 SAE_2016-01-1110_2016-04-05_Improvement of Temperature Prediction Method for Traction Contact

安全报告 > 其他 > 文档预览
中文文档 11 页 50 下载 1000 浏览 0 评论 0 收藏 3.0分
温馨提示:本文档共11页,可预览 3 页,如浏览全部内容或当前文档出现乱码,可开通会员下载原始文档
SAE_2016-01-1110_2016-04-05_Improvement of Temperature Prediction Method for Traction Contact 第 1 页 SAE_2016-01-1110_2016-04-05_Improvement of Temperature Prediction Method for Traction Contact 第 2 页 SAE_2016-01-1110_2016-04-05_Improvement of Temperature Prediction Method for Traction Contact 第 3 页
下载文档到电脑,方便使用
本文档由 SC2023-05-19 13:49:52上传分享
给文档打分
您好可以输入 255 个字符
网站域名是多少( 答案:github5.com )
评论列表
  • 暂时还没有评论,期待您的金玉良言
站内资源均来自网友分享或网络收集整理,若无意中侵犯到您的权利,敬请联系我们微信(点击查看客服),我们将及时删除相关资源。